Royal Enfield Royal Enfield Royal Enfield Royal Enfield Royal Enfield
Select Country

Select Region

Select Country

S. NO. DESCRIPTION PERIODICAL MAINTENANCE (Whichever is earlier)
  Km (x1000) 0.5 5 10 15 20 25 30 35 40 45 50
  miles (x1000) 0.3 3 6 9 12 15 18 21 24 27 30
  Months 1.5 6 12 18 24 30 36 42 48 54 60
1 Engine Oil (#) R   R   R   R   R   R
Check level at every 1000 km or earlier and top up as required
2 Engine Oil Filter(#) R   R   R   R   R   R
3 Inlet and exhaust valve clearance     I   I   I   I   I
4 Spark Plug I I I I R I I I R I I
5 HT Lead I I I I I I I I I I I
6 Rubber hose, Air filter to throttle body I I I I I I I I I I I
7 Rubber hose, Inlet manifold / Adapter I I I I I I I I I I I
8 Evaporative emission equipment rubber hoses I I I I I I I I I I I
9 Fuel filter external         R       R    
10 Air filter element C C R C R C R C R C R
Clean / Replace more frequently if operated in dusty condition
11 Vent pipe under air filter box I I I I I I I I I I I
12 Accelerator and throttle pulley cables free play A A A A A A A A A A A
13 Clutch cable / lever free play Adjust every 1000 km or earlier as required
14 Hand levers pivot point Lubricate every 1000 km or earlier as required
15 Brake pads - Front and Rear I I I I I I I I I I I
16 Disc brake fluid level - Front and Rear I I I I R I I I R I I
17 Rear brake pedal and gear change pedal pivot L L L L L L L L L L L
18 Brake hose and banjo bolt - Front and rear I I I I I I I I I I I
19 Headstock bearings I I I I I I I I I I I
20 Rear wheel drive chain Lubricate and adjust every 1000 km/clean, lubricate and adjust
every service or earlier as required
21 Rear wheel cush rubbers       I       I      
22 Spokes tightness/wheel rim run out front and rear
(It is applicable for spokes wheel model)		 I I I I I I I I I I I
23 Battery terminals (apply petroleum jelly) I I I I I I I I I I I
24 Earth wire eyelet tightness     I   I   I   I   I
25 Tyre wear pattern front and rear I I I I I I I I I I I
26 Pivot-side stand L L L L L L L L L L L
27 Rider and pillion footrest pivot L L L L L L L L L L L
28 All mounting fasteners in vehicle for tightness** I I I I I I I I I I I

A : Adjust C : Clean I : Inspect (Clean, Adjust, Lubricate or replace if necessary) L : Lubricate R : Replace

(#) - After first service, engine oil and engine oil filter replacement is a mandatory at every 12 months even the vehicle has not covered the specified kilometre.

(**) - If any fastener found loose tighten to the specified torque.

NOTE -For maintenance after 50,000 km, please repeat the same frequency specified above, in consultation with a Royal Enfield

Authorised Dealer / Service Centre.
Close